Lockheed NF-104A

NF-104A
Lockheed NF-104A, 56-0756, climbing with rocket power
Role	Aerospace trainer
Manufacturer	Lockheed Aircraft Corporation
Designer	Clarence "Kelly" Johnson
First flight	9 July 1963
Introduction	1 October 1963
Retired	June 1971
Primary user	United States Air Force
Number built	3
Unit cost	$5,363,322 (modification cost for all three aircraft)
Developed from	F-104A Starfighter

The Lockheed NF-104A was an American mixed power, high-performance, supersonic aerospace trainer that served as a low cost astronaut training vehicle for the X-15 and projected X-20 Dyna-Soar programs.

Three aircraft were modified from existing Lockheed F-104A airframes and served with the Aerospace Research Pilots School between 1963 and 1971, the modifications included a small supplementary rocket engine and a reaction control system for flight in the upper atmosphere. During the test program the maximum altitude reached was over 120,000 ft (36,600 m). One of the aircraft was destroyed in an accident while being flown by Chuck Yeager. The accident was depicted in the book The Right Stuff and the film of the same name.

Development

With the advent of manned spaceflight in the early 1960s, the United States Air Force Experimental Flight Test Pilot's School at Edwards Air Force Base was renamed the Aerospace Research Pilots School (ARPS), with the emphasis on training moving away from the traditional test pilot course to a more spaceflight oriented curriculum.^[1]

Initial use of unmodified F-104 aircraft

A number of standard production F-104 Starfighters were obtained (including F-104D two-seat versions)^[2] and used by the ARPS to simulate the low lift/high drag glide approach path profiles of the X-15 and the projected X-20 Dyna-Soar program. These maneuvers were commenced at 12,000 ft (3,700 m) where the F-104 engine was throttled back to 80% power; and with the flaps, speedbrakes and landing gear extended, the aircraft was established in a 30˚ dive with a pull-out for the landing flare starting at 1,500 ft (460 m) above the ground. These glide approaches gave little room for error. A modified Gulfstream G-II has been used by NASA for similar training for the Space Shuttle program.

Reaction Control System

JF-104 during RCS testing.

It was realized that normal aircraft control surfaces had little or no effect in the thin atmosphere of the stratosphere and that any aircraft operating at extremely high altitudes would need to be equipped with a reaction control system (RCS). A modified version of the Bell X-1 was used for initial RCS tests, but was grounded after technical problems and was replaced with a NASA-modified Lockheed F-104A (55-2961) in 1959 which carried RCS systems on its wing tips and in the fuselage nose. This aircraft (designated JF-104) achieved a maximum altitude of 83,000 ft (25,000 m) during the test program. Pilots who flew this aircraft included Neil Armstrong who gained valuable experience in using the RCS system. Pilots complained that the instrument displays were difficult to read and were not accurate enough for the critical zoom climb profiles required to reach high altitudes.^[3]

Lockheed contract

Lockheed was awarded a contract by the USAF to modify three F-104A aircraft for the dedicated role of aerospace trainer (AST) in 1962. The airframes were taken out of storage at AMARC and transported to the company factory for modification.

Design and flight profile

The F-104A design was already established as a lightweight, high performance aircraft; but for the AST project, emphasis was placed on removing unnecessary equipment, fitting a rocket engine to supplement the existing jet engine, fitting an onboard RCS system and improving the instrumentation required. The following details give the main differences between the production version and the AST:

Wing

The wingspan of the NF-104A was increased by adding tip extensions to the existing planform. This modification was needed to house the RCS roll control thrusters and would also decrease the type's wing loading.

Tail surfaces

The vertical fin and rudder were replaced by the larger area versions from the two-seat F-104 and were structurally modified to allow installation of the rocket engine.

Fuselage

The fiberglass nose radome was replaced with an aluminum skin and housed the pitch and yaw RCS thrusters. The air intakes originally designed by Ben Rich were of the same fixed geometry as the F-104A but included extensions to the inlet shock cones for optimum jet engine operation at higher Mach numbers. Internal fuselage differences included provision for rocket fuel oxidizer tanks, deletion of the M61 Vulcan cannon, Radar equipment and unnecessary avionics. A nitrogen tank was installed for cabin pressurization purposes, this was required as there would be no bleed air available from the engine after its normal and expected cutoff in the climb phase. Contrary to popular misconception, the jet engine was not allowed to flameout but had to be gradually throttled down and then cutoff as EGT temperatures ramped up towards the danger point for the turbojet's integrity.

Rocket engine

In addition to the standard J79 jet engine a Rocketdyne AR2-3 rocket engine was fitted at the base of the vertical fin. This engine burned a mixture of JP-4 jet fuel and 90% hydrogen peroxide oxidizer solution. The NF-104 carried enough oxidizer for approximately 100 seconds of rocket engine operation. The thrust level could be adjusted to maximum or approximately half power by the pilot using an additional throttle lever on the left side of the cockpit.

Reaction Control System

The Reaction Control System(RCS) consisted of eight pitch/yaw motors (four for each axis) and four roll motors. They used the same kind of hydrogen peroxide fuel as the main rocket engine from a dedicated 155 lb (70 kg) fuel tank and were controlled by the pilot using a handle mounted in the instrument panel. The pitch/yaw motors were rated at 113 lbf (500 N) thrust each and the roll motors were rated at 43 lbf (190 N) thrust.

Typical flight profile

Chuck Yeager in the cockpit of an NF-104A, 4 December 1963

The NF-104A was able to reach great altitudes through a combination of zoom climbing (trading speed for altitude) and use of the rocket engine. A typical mission involved a level acceleration at 35,000 ft (11,000 m) to Mach 1.9 where the rocket engine would be ignited, and on reaching Mach 2.1 the aircraft would be pitched up to a climb angle of 50-70° by carefully applying a load equal to 3.5 g. The J79 afterburner would start to be throttled down at approximately 70,000 ft (21,000 m) followed shortly after by manual fuel cutoff of the main jet engine itself around 85,000 ft (26,000 m) to prevent fast rising engine temperatures from damaging the turbojet. After continuing over the top of its ballistic arc the NF-104 would descend back into denser air where the main engine could be restarted using the windmill restart technique for recovery to a landing.^[4]

Operational history

First NF-104A

The first NF-104A (USAF 56-0756) was accepted by the USAF on 1 October 1963. It quickly established a new unofficial altitude record of 118,860 ft (36,230 m) and surpassed this on 6 December 1963 by achieving an altitude of 120,800 ft (36,800 m). It suffered an inflight rocket motor explosion in June 1971. Although the pilot was able to land safely, the damaged aircraft was retired and marked the end of the NF-104 project. This aircraft was reported as scrapped.

Second NF-104A

NF-104A Tail Number 760 at the USAF Test Pilot School

The second NF-104A (USAF 56-0760) was accepted by the USAF on 26 October 1963. After retirement, this aircraft was mounted on a pole outside the U.S. Air Force Test Pilot School at Edwards Air Force Base and can still be seen there today. The extended wing tips, RCS metal nose cone and other parts from 56-0760 were loaned to Daryl Greenamyer for his civilian aviation record attempts using a highly modified F-104. When he was forced to eject during a record flight, his aircraft was destroyed and the parts were never returned.^[5]

Third NF-104A

The third NF-104A (USAF 56-0762) was delivered to the USAF on 1 November 1963, and was destroyed in a crash while being piloted by Chuck Yeager on 10 December 1963. This accident was depicted in the book The Right Stuff and the film of the same name; although the aircraft used for filming was a standard F-104G flying with its wingtip fuel tanks removed, but otherwise lacking any of the NF-104A's modifications, most visibly the rocket engine pod at the base of the vertical stabilizer.^[6]

Operators

 United States

• United States Air Force

Specifications (NF-104A)

Data from Libis,^[7]

General characteristics

• Crew: 1
• Length: 54 ft 9 in (16.6 m)
• Wingspan: 25 ft 9 in (7.84 m)
• Height: 13 ft 6 in (4.1 m)
• Wing area: 212.8 ft² (19.77 m²)
• Airfoil: Bi-convex 3.36%
• Empty weight: 13,500 lb (6,080 kg)
• Loaded weight: 21,400 lb (9,890 kg)
• Max takeoff weight: 21,400 lb (9,890 kg)
• Powerplant:
  • 1 × General Electric J79-GE-3B turbojet, 9,600 lbf (43.54 kN)
  • 1 × Rocketdyne AR2-3 liquid fuelled rocket engine, 6,000 lbf (27.2 kN)

Performance

• Maximum speed: Mach 2.2

See also

• Century Series
• Robert Henry Lawrence, Jr.
  

Related development

• Lockheed XF-104
• F-104 Starfighter
• Canadair CF-104
• Aeritalia F-104S
• CL-1200 Lancer and Lockheed X-27
  

Aircraft of comparable role, configuration and era

• Saunders-Roe SR.53
• Saunders-Roe SR.177
  

Related lists

• List of fighter aircraft
• List of military aircraft of the United States
• List of F-104 Starfighter operators
• List of rocket planes
  

References

Notes

1. ^ Libis 1999, p. 2.
2. ^ Drendel 1976, p.24.
3. ^ Libis 1999, p. 5.
4. ^ Bowman 2000, p. 173.
5. ^ Libis 1999. p. 39.
6. ^ Check-Six.com - The Crash of Yeager's NF-104
7. ^ Libis 1999, p. 41.

Bibliography

• Bowman, Martin W. Lockheed F-104 Starfighter. Ramsbury, Marlborough, Wiltshire, UK: Crowood Press Ltd., 2000. ISBN 1-86126-314-7.
• Drendel, Lou. F-104 Starfighter in action, Aircraft No. 27. Carrollton, Texas: Squadron/Signal Publications, 1976. ISBN 0-89747-026-5.
• Kinzey, Bert F-104 Starfighter in Detail & Scale. Blue Ridge Summit, PA: TAB books, 1991. ISBN 1-85310-626-7.
• Libis, Scott. Lockheed NF-104A Aerospace Trainer (Air Force Legends Number 204). Simi Valley, CA: Steve Ginter, 1999. ISBN 0-942612-97-3.
• Pace, Steve. F-104 Starfighter: Design, Development and Worldwide Operations of the First Operational Mach 2 Fighter. St. Paul, MN: Motorbooks International, 1992. ISBN 0-87938-608-8.
• Reed, Arthur. F-104 Starfighter (Modern Combat Aircraft 9). London: Ian Allan Ltd., 1981. ISBN 0-7110-1089-7.
• Upton, Jim. Lockheed F-104 Starfighter (Warbird Tech). North Branch, MN: Specialty Press, 2003. ISBN 1-58007-069-8.

External links

• NF-104.com
• Joe Baugher NF-104 page