Coaxial rotors

Coaxial rotors
Kamov Ka-32A-12

Coaxial rotors are a pair of helicopter rotors mounted one above the other on concentric shafts, with the same axis of rotation, but that turn in opposite directions (contra-rotation). This configuration is a feature of helicopters produced by the Russian Kamov helicopter design bureau.


Design considerations

Angular momentum

One of the problems with any single set of rotor blades is the tendency of the helicopter body to begin spinning in the opposite direction to that of the rotors once airborne. This is due to the principle of conservation of angular momentum: The engines of the helicopter, by exerting torque on the rotor blades, give a sizable amount of angular momentum to the blades. Absent external forces such as contact with the ground, the angular momentum of the blades must be offset by a change in angular momentum of the body for momentum to be conserved. While the engine spins up the blades, the blades apply equal yet opposite torque to the body, causing the body to gain spin angular momentum in the other direction. This phenomenon would cause the helicopter to lose control if not checked. To counteract the effect, the tail rotor was introduced to provide a constant input of angular momentum to the body opposite in direction to that from the main rotor. Then, the helicopter's fuselage remains stationary and stable level flight becomes possible. Varying the torque exerted by the tail rotor on the body of the helicopter (hence changing the magnitude of the angular momentum input) facilitates controlled turning. This gives the helicopter extreme maneuverability, and the helicopter can hover and pivot about the rotor axis. Control of rotational motion with designs lacking tail rotors is achieved by using two sets of rotor blades rotating in opposite directions, canceling each other's angular momentum.

Coaxial rotors solve the problem of angular momentum by turning each set of rotors in opposite directions. The equal and opposite torques from the rotors upon the body cancel out. Rotational maneuvering, yaw control, is accomplished by increasing the collective pitch of one rotor and decreasing the collective pitch on the other. This causes a controlled dissymmetry of torque.

Dissymmetry of lift

Dissymmetry of lift is an aerodynamic phenomenon that is caused by the rotation of a helicopter's rotors in forward flight. Rotor blades provide lift proportional to the amount of air flowing over them. When viewed from above, the rotor blades move in the direction of flight for half of the rotation (advancing half), and then move in the opposite direction for the remainder of the rotation (retreating half). During the advancing half, a rotor blade produces more lift. As a blade moves toward the direction of flight, the forward motion of the aircraft increases the speed of the air flowing around the blade until it reaches a maximum, when the blade is perpendicular to the relative wind. At the same time, a rotor blade in the retreating half produces less lift. As a blade moves away from the direction of flight, the speed of the airflow over the rotor blade is reduced by an amount equal to the forward speed of the aircraft, reaching its maximum effect when the rotor blade is again perpendicular to the relative wind. Coaxial rotors reduce the effects of dissymmetry of lift through the use of two rotors turning in opposite directions, causing blades to advance on either side at the same time.

Other benefits

One other benefit arising from a coaxial design include increased payload for the same engine power — a tail rotor typically wastes some of the power that would otherwise be devoted to lift and thrust, whereas with a coaxial rotor design, all of the available engine power is devoted to lift and thrust. Reduced noise is a second advantage of the configuration — part of the loud 'slapping' noise associated with conventional helicopters arises from interaction between the airflows from the main and tail rotors, which in some designs can be severe. Also, helicopters using coaxial rotors tend to be more compact (occupying a smaller 'footprint' on the ground), though at the price of increased height, and consequently have uses in areas where space is at a premium — several Kamov designs are used in naval roles, being capable of operating from confined spaces on the decks of ships, including ships other than aircraft carriers (an example being the Kara Class cruisers of the Russian navy, which carry a Ka-25 'Hormone' helicopter as part of their standard fitment). Another benefit is increased safety on the ground; by eliminating the tail rotor, the major source of injuries and fatalities to ground crews and bystanders is eliminated.


A principal disadvantage of the coaxial rotor design is the increased mechanical complexity of the rotor hub. The linkages and swashplates for two rotor systems need to be assembled atop the mast, which is more complex because of the need to drive two rotors in opposite directions. Because of the greater number of moving parts and complexity, the coaxial rotor system is more prone to mechanical faults and possible failure.[citation needed] However, US Army experience from the Vietnam War indicates that damage to the tail rotor and the long driving shaft, from enemy fire or treetop collisions, was the most frequent cause of helicopter losses, so from a military viewpoint the issue may be more complex. Also Kamov maintains that its coaxial assembly is built to withstand direct hits from 20 mm cannon fire and presents a small target. Kamov does have a good mechanical reliability record from use in demanding conditions including offshore oil rigs and Russian Navy vessels.

Coaxial models

This Heli-Max Axe Micro CX model helicopter is an example of a micro-sized coaxial model. Note the size comparison with the cellular telephone at right. Also note that the tail rotor is non-functional and for aesthetic purposes only.

The system's inherent stability has, in recent years, made it a good candidate for the design of small radio controlled helicopters for beginner and/or indoor use. Models of this type, as in the case of a full-scale helicopter, eliminate rotational torque and extremely quick control response, both of which are very pronounced in a CCPM model.

While such a model is extremely stable and can be flown indoors even in tight quarters, a coaxial model helicopter has limited forward speed, especially outdoors. Most such models are fixed-pitch (i.e., the blades do not rotate on their axes), which simplifies the model, but eliminates the ability to compensate with collective input. Compensating for even the slightest breeze causes the model to climb rather than to fly forward even with full application of cyclic.

Hazards of helicopter flight

The U.S. Department of Transportation has published a “Basic Helicopter Handbook”. One of the chapters in it is titled, “Some Hazards of Helicopter Flight'. Ten hazards have been listed to indicate what a typical single rotor helicopter has to deal with. The unique coaxial rotor design either reduces or completely eliminates these hazards. The following list indicates which:

  • Settling with power — Reduced
  • Retreating blade stall — Reduced
  • Medium frequency vibrations — Reduced
  • High frequency vibrations — None
  • Anti torque system failure in forward flight — Eliminated
  • Anti torque system failure while hovering — Eliminated

The reduction and elimination of these hazards are the strong points for the safety of coaxial rotor design.[1][2]

List of co-axial rotor helicopters

Russian Air Force Ka-52, a two seat variant of the Ka-50.

See also


External links

Wikimedia Foundation. 2010.

Игры ⚽ Нужен реферат?

Look at other dictionaries:

  • coaxial rotors — A rotor system in which two rotors are mounted on the helicopter rotating in the opposite direction but running on concentric shafts. There is thus no residual torque …   Aviation dictionary

  • Coaxial — Câble coaxial « Coaxial » redirige ici. Pour rotors principaux coaxiaux, voir rotor contrarotatif. Le câble coaxial ou ligne coaxiale est une ligne de transmission ou liaison asymétrique, utilisée en hautes fréquences, composée d un… …   Wikipédia en Français

  • Intermeshing rotors — on a helicopter are a set of two rotors turning in opposite directions, with each rotor mast mounted on the helicopter with a slight angle to the other so that the blades intermesh without colliding. The arrangement allows the helicopter to… …   Wikipedia

  • Tandem rotors — Tandem rotor (sometimes referred to as dual rotor) helicopters have two large horizontal rotor assemblies; a twin rotor system, instead of one main assembly and a smaller tail rotor.Single rotor helicopters need a tail rotor to neutralize the… …   Wikipedia

  • Cable coaxial — Câble coaxial « Coaxial » redirige ici. Pour rotors principaux coaxiaux, voir rotor contrarotatif. Le câble coaxial ou ligne coaxiale est une ligne de transmission ou liaison asymétrique, utilisée en hautes fréquences, composée d un… …   Wikipédia en Français

  • Câble Coaxial — « Coaxial » redirige ici. Pour rotors principaux coaxiaux, voir rotor contrarotatif. Le câble coaxial ou ligne coaxiale est une ligne de transmission ou liaison asymétrique, utilisée en hautes fréquences, composée d un câble à deux… …   Wikipédia en Français

  • Câble coaxial — « Coaxial » redirige ici. Pour rotors principaux coaxiaux, voir rotor contrarotatif. Le câble coaxial ou ligne coaxiale est une ligne de transmission ou liaison asymétrique, utilisée en hautes fréquences, composée d un câble à deux… …   Wikipédia en Français

  • Helicopter rotor — This article is about helicopter main rotor systems. For antitorque control, see tail rotor. Helicopter rotor The rotor head of a Sikorsky S 92 A helicopter main rotor or rotor system is a type of fan that is used to generate both the aerodynamic …   Wikipedia

  • Helicopter — For other uses, see Helicopter (disambiguation). Helicopter An LAPD Bell 206 …   Wikipedia

  • E-Sky Lama model helicopters — The E Sky Lama family of model helicopters comprises small, 4 channel, remote controlled electric coaxial helicopters produced by E Sky. These include the original Lama, the Lama V2, Lama V3 and Lama V4, a series of coaxial remote control… …   Wikipedia

Share the article and excerpts

Direct link
Do a right-click on the link above
and select “Copy Link”