D&RGW K-27

D&RGW K-27 Class
#453 in 1940
Power type	Steam
References:[1][2]
Builder	Baldwin Locomotive Works
Build date	1903
Configuration	2-8-2
UIC classification	1′D1′ v, later 1′D1′ h
Gauge	3 ft  (914 mm)
Leading wheel diameter	28 in (711 mm)
Driver diameter	40 in (1,016 mm)
Trailing wheel diameter	28 in (711 mm)
Wheelbase	24.5 feet (7.5 m)
Length	33.7 feet (10.3 m)
Weight on drivers	105,425 lb (48 t)
Locomotive weight	136,650 lb (62 t)
Fuel type	Coal
Boiler pressure	200 lbf/in² (1.38 MPa)
Cylinders	Original: Four Vauclain compound, Later: Two, simple
Cylinder size	Original: 13 × 22 in (330 × 559 mm) and 22 × 22 in (559 × 559 mm) Later: 17 × 22 in (432 × 559 mm)
Valve gear	see table
Valve type	see table
Tractive effort	27,000 lbf (120 kN)
Locomotive brakes	Air
Train brakes	Air
Career	Denver & Rio Grande Denver & Rio Grande Western Rio Grande Southern Cumbres & Toltec Scenic Huckleberry Railroad
Class	D&RG: 125 D&RGW: K-27
Number in class	15
Number	450-464
Nicknames	Mudhen
Locale	California, Colorado, Mexico, Michigan, New Mexico
Preserved	Two: #463, 464

The D&RGW K-27 class are 3 foot narrow gauge, Mikado type, 2-8-2 steam railway locomotives built for the Denver and Rio Grande Railroad by the Baldwin Locomotive Works in 1903. They eventually became known by the nickname "Mudhens".

Fifteen locomotives were built, originally class 125, reclassified K-27 in 1924 when the Denver and Rio Grande became the Denver and Rio Grande Western Railroad. The K-27s were built as Vauclain compounds, with two cylinders on each side, expanding the steam once in the smaller cylinder and then a second time in the larger one. The extra maintenance costs of the two cylinders were greater than the fuel saving, so they were converted to simple expansion in 1907–1909. They were Rio Grande's last purchase of compound locomotives. They were built with their main structural frames outside the driving wheels, with the counterweights and rods attached outside the frames.^[2]

They had one peculiarity which arose from their outside frames and counterweights. In places where the D&RG's standard gauge system met the narrow gauge system, the railroad operated dual gauge trackage, with three rails, so that standard gauge equipment ran on the outer two rails and three foot gauge equipment ran on one of the outer rails and a third rail, inside the other two. Since the narrow gauge equipment was much lighter than the standard gauge, the inner rail was generally lighter and, therefore, not as tall as the standard gauge rails. In the case of the D&RGW, the difference was ⅞ inch (22 mm). Because the counterweights were outside the frames, they ended up directly over the standard gauge rail, with a clearance of only about ⅝ inch (16 mm). When the shop crews trued up the drivers periodically, they had to be very careful not to go too far.^[2]

They pulled freight, passenger and mixed trains on the D&RGW in and over the Colorado Rocky Mountains, traversing the entire length of the railroad. Many of them also spent time on the Rio Grande's subsidiary, the Rio Grande Southern.

Preservation

Main article: D&RGW 463

Number 463, was sold to cowboy actor and singer Gene Autry in May 1955. Autry never used the Mudhen and donated it to the City of Antonito, Colorado. It was restored by and entered into service on the Cumbres and Toltec Scenic Railroad in 1994. It was taken out of service with a broken side rod in 2002. In 2009, it was moved to the railroad's shop at Chama, New Mexico where a major rebuild is underway.^[3] 463 was added to the National Register of Historic Places in 1975 as Engine No. 463.

The other K-27 in existence is 464. It sat outside in Durango, Colorado during the 1960s and was sold to Knott's Berry Farm in 1973. It saw little or no use there, in part because of its condition and in part because of the counterweight clearance problem described above. The Huckleberry Railroad in Flint, Michigan, acquired the locomotive in 1981, did an eight-year restoration on it, and put it into active service.^[4][5]

Details

The K-27s went through a variety of modifications during their 36 to 107+ years of service. They ended up in three distinct groups, with many different details such as the location of the air tanks, whether or not they had a doghouse on the tender for the head brakeman, and so forth. The most important of these details are:^[2]

Number	Builder's Number	Equipment after rebuild	Ultimate Disposition
450	21677	slide valve cylinders	Scrapped 1939
451	21685	slide valve cylinders	Scrapped 1939
452	21803	piston valves outboard of cylinders, Walschaerts valve gear, superheater	Scrapped 1954
453	21824	piston valves outboard of cylinders, Walschaerts valve gear, superheater	Scrapped 1954
454	21832	piston valves inboard of cylinders, Walschaerts valve gear, superheater	Scrapped, 1953
455	21845	piston valves outboard of cylinders, Walschaerts valve gear, superheater	Traded to RGS, wrecked 1943, rebuilt 1947 using parts from a standard gauge locomotive, scrapped 1953
456	21854	piston valves inboard of cylinders, Walschaerts valve gear, superheater	Scrapped 1956
457	21894	slide valve cylinders	Scrapped 1939
458	21910	piston valves inboard of cylinders, Walschaerts valve gear, superheater	Sold to National Railways of Mexico, converted to standard gauge 1950, scrapped in 1963
459	21936	piston valves outboard of cylinders, Walschaerts valve gear, superheater	Sold to National Railways of Mexico, converted to standard gauge 1950, scrapped 1957
460	21728	slide valve cylinders	Scrapped 1939
461	21729	piston valves inboard of cylinders, Walschaerts valve gear, superheater	Sold to RGS, scrapped 1961
462	21781	piston valves outboard of cylinders, Walschaerts valve gear	Scrapped 1950
463	21788	piston valves outboard of cylinders, Walschaerts valve gear, superheater	To Gene Autry, 1955 Then static display at Antonito Now: operational (in shops 2010) on the C&TS
464	21796	piston valves outboard of cylinders, Walschaerts valve gear, superheater	Static display at Durango To Knotts Berry Farm, 1973 Now operational on the Huckleberry Railroad

References

1. ^ Official Roster No. 11 of the Denver and Rio Grande Western Railroad System. Denver: The Denver and Rio Grande Western Railroad System. April 1, 1923. p. 94. 
2. ^ ^{a b c d} Brewster, Allen J. (March and June, 1973). "D&RG's K-27, parts 1 and 2". Model Railroader (Milwaukee: Kalmbach). 
3. ^ "A chronicle of the rebuilding of D&RGW locomotive #463". DRGW463.COM. http://www.drgw463.com/. Retrieved 6 February 2010. 
4. ^ "Denver & Rio Grande Locomotive History: 464". Rio Grande Modeling and Historical Society. http://www.drgw.org/data/steam/history/drg464.htm. Retrieved 28 January 2010. 
5. ^ "Primary Locomotives of the Huckleberry Railroad, #2 and #464". Huckleberry Railroad. http://www.geneseecountyparks.org/huckleberry_railroad.htm. Retrieved 6 February 2010. ^{[dead link]}

• O'Berry, Dennis. (1995). The Mudhens, A Photographic History.