- 2002 airtanker crashes
In 2002, two large
airtanker s – aC-130 Hercules and a P4Y-2 Privateer – crashed about a month apart while performingaerial firefighting operations. These crashes prompted a review of the maintenance and use of the entire U.S. large airtanker fleet. Ultimately, the whole fleet (33 aircraft in all) was grounded, dramatically reducing the resources available to fight majorwildfire s. Both aircraft were owned byHawkins & Powers Aviation ofGreybull, Wyoming and operated under contract to theU.S. Forest Service (USFS). The crashes occurred in one of "the worst fire seasons in the last half century, one in which 73,000 fires burned approximately 7.2 million acres (29,000 km²)of land."C-130A, N130HP, Walker, California
N130HP, call sign "Tanker 130", was flying against the Cannon Fire, [The Cannon Fire started
June 15 2002 and was 100% contained onJune 28 2002 , after burning convert|22750|acre|km2|1 [http://www.yubanet.com/cannon.shtml] ] nearWalker, California onJune 17 2002 , when it experienced structural failure of the center wing section, causing both wings to fold upward and separate from the aircraft. Thefuselage rolled and crashed inverted, killing the three crew members on board. [http://www.ntsb.gov/ntsb/brief2.asp?ev_id=20020621X00954&ntsbno=LAX02GA201&akey=1 NTSB accident brief LAX02GA201 for N130HP] ]Tanker 130 had departed the
Minden, Nevada air attack base at 2:29 p.m. PDT with 3,000 gallons (11,000 l) of retardant for its sixth drop of the day, and arrived at the fire at 2:45 p.m. The crew made an initial spotting pass over the drop zone, then flew back for the drop, which was to be a 1/2 salvo, dispensing half of the onboard retardant. The drop run required the aircraft to make a perpendicular crossing of a ridgeline and then descend into a valley. A video of the accident shows the aircraft crossing the ridge and then pitching down to begin its drop of the retardant. Near the end of the drop, the nose of the aircraft began to pitch up to level attitude as the descent was arrested. The nose continued to pitch up past level attitude, and at the end of the drop, the right wing began to fold upwards, followed less than one second later by the left wing. Two debris fields were found, one 500 feet (152 m) in length and the other 720 feet (219 m) in length. A post-impact fire in the first debris field consumed major portions of the wing and engine components; there was no fire in the second debris field, which included the fuselage andempennage .The aircraft, serial number 56-0538, was one of the original C-130 production series and had been built by
Lockheed in 1957. It was retired from military service in 1978 and stored atDavis-Monthan Air Force Base for ten years. In May 1988, the aircraft was acquired by the U.S. Forest Service from theGeneral Services Administration , and in August 1988 the Forest Service sold the plane to Hemet Valley Flying Service along with five others it had acquired, for conversion to an airtanker. Hemet then sold the C-130 to Hawkins & Powers. At the time of the crash, the airframe had logged 21,863 flight hours.The
National Transportation Safety Board (NTSB) investigated the crash and determined that the accident was caused by a structural failure which occurred at the wing-to-fuselage attach point, with the right wing failing just before the left one. The investigation disclosed "evidence of fatigue cracks in the right wing's lower surface skin panel, with origins beneath the forward doubler.... The origin points were determined to be in rivet holes which join the external doubler and the internal stringers to the lower skin panel. These cracks, which grew together to about a 12-inch (30-cm) length, were found to have propagated past the area where they would have been covered by the doubler and into the stringers beneath the doubler and across the lap joint between the middle skin panel and the forward skin panel." [http://www.ntsb.gov/pressrel/2002/020924.htm "Update on Investigations of Firefighting Airplane Crashes in Walker, California and Estes Park, Colorado", National Transportation Safety Board,September 24 2002 , retrievedSeptember 6 2007 ] ]P4Y-2, N7520C, Estes Park, Colorado
The second crash occurred on
July 18 2002 nearEstes Park, Colorado , also as a result of structural failure, in this case in the wing's spar adjacent to the left side of the fuselage. The aircraft, "Tanker 123", was loaded with 2,000 gallons (7,600 l) of retardant.cite web |url=http://www.thedenverchannel.com/news/1564853/detail.html |title=2 Killed When Air Tanker Fighting Big Elk Fire Crashes |accessdate=2007-09-10 |last=Harrison |first=Wayne |coauthors= |date=2002-07-18 |work=ABC 7 News |publisher=] At the time of the accident, it was in a left turn from downwind to final approach for its eighth drop of the day on the Big Elk fire. [The Big Elk Fire ultimately burned convert|4400|acre|km2|1, according to the [http://www.coloradopreservation.org/preservationist/issues/cpm_02_fal.pdf "Colorado Preservationist"] ] While still in the 15°-20° left bank, witnesses on the ground and in another tanker observed the left wing separate from the aircraft and "fold upwards", followed almost immediately by the initiation of a fire. The aircraft continued to roll left, impacting the ground at a 45° nose down attitude, starting a large fire at the wreck site. Both crew members were killed in the crash. [http://www.ntsb.gov/ntsb/brief2.asp?ev_id=20020726X01227&ntsbno=DEN02GA074&akey=1 NTSB brief DEN02GA074 for N7520C] ]The aircraft, a Consolidated-Vultee PB4Y-2, BuNo 66260, (the designation was later changed by the Navy to P4Y-2), was a variant of the
World War II B-24 Liberator . It had been delivered in July, 1945 to the U.S. Navy who used it for coastal patrol duties. In 1952, it was transferred to the U.S. Coast Guard, who flew it until it was retired in 1956. The aircraft was pulled out of storage and converted to an airtanker in 1958, and was flown by several different companies, the last being Hawkins & Powers. At the time of the crash, the airframe had logged 8,346.3 flight hours.A detailed investigation by the NTSB showed that the wing's lower spar cap had extensive stress fatigue and had fractures through the lower spar cap, vertically up the spar web and into the upper spar cap. The lower wing skin also found signs of fatigue in the area adjacent to the cracked spar cap. An examination of two other similar aircraft showed that the area of cracking was hidden from view by other fuselage structure.
Prior safety concerns and incidents
Concerns about the safety of older transport aircraft being used as airtankers had been ongoing, long before the 2002 crashes. In the early 1980s, concern about the age and safety issues of World War II and
Korean War -era aircraft that were the predominant aircraft used as airtankers led the Forest Service to initiate a program to provide more modern, turbine-powered C-130As to contracting companies. However, this solution quickly became the problem. According to an NTSB advisory, "During a C-130A contract pre-award evaluation in 1991, the Department of the Interior's (DOI) Office of Aviation Services inspectors concluded that essential inspection and maintenance services critical to sustaining the airplane in an airworthy condition under normal operating conditions were not being accomplished with the C-130A. This prompted the DOI, in 1993, to prohibit the use of the C130A on DOI land. The FAA and the DOI subsequently developed an action plan to address many of the same inspection and maintenance issues seen in the most recent C130A and P4Y accident investigations. Since that time the DOI has dropped its restrictions on the C130A...."On
August 13 1994 , C-130A N135FF, call sign "Tanker 82," crashed nearPearblossom, California while fighting a fire in theSan Gabriel Mountains . Eyewitnesses reported seeing an explosion followed by the separation of the right wing at the wing attach point. [http://www.ntsb.gov/ntsb/brief2.asp?ev_id=20001206X02066&ntsbno=LAX94FA323&akey=1 NTSB Accident Brief LAX94FA323 for N135FF] ] Due to the extremely rugged terrain, the NTSB recovered only a small portion of the wreckage, and its preliminary conclusion that an explosion caused by a fuel leak led to the wing separation was based largely on eyewitness statements. [http://www.iasa.com.au/folders/Publications/Legal_Issues/PearblossomC130.html Dornheim, Michael A., "Hidden Fatigue Cracks Suspected in C-130 Crash", "Aviation Week & Space Technology", archived at International Aviation Safety Association] ] A subsequent independent investigation in 1997 led by Douglas Herlihy, a former NTSB investigator, reexamined the site and the wreckage, and found no evidence of an explosion, but rather found evidence of structural failure due to fatigue stress. [http://findarticles.com/p/articles/mi_m0UBT/is_25_16/ai_87717208 "Competing Conclusions Surround Earlier Firefighting Propjet Crash", "Air Safety Week",June 24 2002 , retrieved from FindArticles.com onSeptember 8 2007 ] ] The NTSB subsequently reexamined its findings, and found evidence of fatigue cracking "consistent with overstress separation", and ultimately revised their findings. [http://www.ntsb.gov/Pressrel/2004/040423.htm "NTSB Recommends Rigorous Maintenance Programs for Firefighting Aircraft", NTSB news release,April 23 2004 , retrievedSeptember 8 2007 ] ] The initial eyewitness reports of an explosion are not inconsistent with a fatigue-caused wing separation. Similar eyewitness reports were given in the 2002 crash, and an analysis of a video of that crash showed the initiation of a fireball 0.9 seconds after the wing separated.On
September 6 2000 , a C-130A, former USAF 56-0478, c.n. 3086, N116TG operated by T&G Aviation, fighting a fire nearBurzet ,France crashed killing two of the four on board. [cite web |url=http://news.bbc.co.uk/2/hi/europe/913147.stm |title=Two die in French fire-fighting crash |accessdate=2007-09-07 |last= |first= |coauthors= |date=2000-09-06 |work=BBC |publisher=] [http://www.ntsb.gov/ntsb/brief.asp?ev_id=20001212X21996&key=1 NTSB Brief IAD00WA083] ] It struck a ridge while preparing for a second drop on the fire.Fleet grounding
Following the two crashes, the USFS and the
U.S. Bureau of Land Management (BLM) jointly established an independent blue ribbon panel "to investigate issues associated with aerial wildland firefighting in the United States." [http://www.fs.fed.us/congress/108/senate/oversight/hamilton/032603.html Statement] of Larry Hamilton National Director, Office of Fire and Aviation, Department of the Interior, Bureau of Land Management, National Interagency Fire Center Oversight Hearing: Blue Ribbon Panel Report and Aerial Firefighting Safety, Senate Energy and Natural Resources Committee Subcommittee on Public Lands and Forests,March 26 2003 , retrievedSeptember 27 2007 ] In March, 2003, the panel released its report, which included eight key findings "critical for planning a safe and effective fire aviation program. The Report identified various concerns about aircraft safety, including the airworthiness of aircraft that were operating outside of their original intended design and the appropriate levels of maintenance and training to ensure safe operations. The report also identified a lack of training in contemporary aviation management areas that has contributed to an unacceptable accident rate."As a result of the panel's recommendations, the USFS and BLM declined to renew the leases on nine C-130A and PB4Y-2 airtankers, and ordered the 33 remaining large airtankers to undergo an improved inspection program before they returned to active service. The agencies contracted with the
Sandia National Laboratories to analyze the safety of continuing use of three types of airtankers, the Douglas DC series (DC-4, DC-6 and DC-7),P-3 Orion andP-2 Neptune . In addition, eleven of 19Beechcraft Baron 58P leadplanes were also retired, as they had exceeded the 6,000 flight hour airframe safety limit. To further reduce the risk to the fleet, the agencies directed their field managers to use airtankers primarily for initial attack only.Almost two years after the Summer 2002 crashes and as a direct result of the ensuing investigations, on
May 10 2004 , the Forest Service abruptly terminated the contracts for the entire large tanker fleet. USFS Chief Dale Bosworth stated, "Safety is a core value of the firefighting community, and it is non-negotiable. To continue to use these contract large airtankers when no mechanism exists to guarantee their airworthiness presents an unacceptable level of risk to the aviators, the firefighters on the ground and the communities we serve."cite web |url=http://firechief.com/wildland/large-air-tankers/ |title=Feds Terminate Large Air Tanker Fleet |accessdate=2007-09-07 |last=West |first=Pat |coauthors= |date=2004-05-12 |work=Fire Chief |publisher=] The decision affected tanker contracts issued by both the USFS and BLM.In the vacuum left by the absence of the large tankers, the Forest Service said it would shift its firefighting strategies to rely more on heavy helicopters, light tankers and military C-130s equipped with the
Modular Airborne FireFighting System .ee also
*
List of C-130 Hercules crashes
*Wildland fire suppression References
External links
* [http://video.google.com/videoplay?docid=4138594795821359020&q=c-130+crash&hl=en C-130 crash video]
* [http://www.ldscops.com/war%20stories/joanna%20hobart.htm Experiences of one of the French C-130 crewmembers]
* [http://www.ruudleeuw.com/tanker130.htm "Tanker 130 Down!", including photos of the aircraft]
Wikimedia Foundation. 2010.